Maintenance log

back to boat

Maintenance Log

need fogging oil, grease,fuel conditioner

1. run with fuel conditioner 5 min

prepare storage mixture

• 2qts gas
• 6oz fogging oil
• 1.6oz 2cycle oil
• $1/4oz fuel conditioner

1. run for 5 minutes
2. remove plugs, add fogging oil, turn crankshaft, replace plugs
3. lube prop
4. change gear oil

spring25

• getting new battery charger, gear oil, water container, tires, winch, rod holder
• didn't change the gear oil
• started first time
• wash and wax, need wax next year

fall24

• need new water container that fits prop
• need new tires 4.80x12 5 lug

• gear Oil NOT changed since longtime 6th

spring 24

• wax
• stripped old blistering varnish on the bow and rear seat, refinished
• pulled old seats cut out rot in seat
• pulled wheels, lubricated
• fixed right trailer light, taped connector
• charged battery at home, charger would shut itself off multiple times, eventually styed on at 2A. Said 100%, then when unplugged and reconnected said 85%.Eventually said 100% AND the charged light came on.

spring 23

5/31/23

• wax but no varnish
• loose and tighten lug nuts
• fill tires

fall 2022

10/27/22

• winterize engine
• fog cylinders
• change gear oil
• pull propeller
• pull wheels and lube

spring 2022

• started right up, ran until it stopped smoking from the fogging oil
• pulled trailer wheels, greased bearings
• DID NOT change gear oil
• trailer lights dead, pin broke off on 4wire flat vehicle side connsector
• up button for trim tilt @ drivers seat is flaky, looks corroded

spring 2021

fastrak tilt not working, ordered new motor, wasn't the problem, returned it. Problem was bad connection at the plug right inside the cover. REMEMBER: to test the hydraulic motor put 12 volt accross the blue and green wires!!!

• no varnish
• clean and wax
• replace crank webbing strap
• pull tires, inflate reinstall
• installed new stainless steel clips on bimini nylon straps

Missing at high speed, slow acceleration, OK at slow speed 5/25/21. Put Spark detector special tool on each plug. All firing

• changed plugs
• rebuilt carbeurators: note high speed orofice is 45D one in plastic top is 35D. mangled one ordered replacement. There is a long black screwdriver perfect for removing orofices (hay 3 more kits
• changed fuel filter (hay spares)
• compression 155 all cylinders

fall 2020

• changed gear oil
• pulled prop
• lubed fittings
• lubed trailer
• removed trailer wheels

spring 2019

Didnt change gear oil